Engine
Cylinder block or barrels and crankcase assemblies (excluding cracks
and porosity) crankshaft, crankshaft bearings, big end bearings,
small/little end bearings, oil pump, con-rods, gudgeon pins, pistons,
piston rings, cylinder bore (excluding cracks and porosity) cylinder
head (excluding cracks & porosity) cylinder head gasket, rocker shafts,
rockers arms, camshafts and cam followers, camshaft bearings, push
rods, inlet and exhaust valves, valve springs, value guides (excluding
two stroke power valve assemblies), timing gears, flywheel (excluding
overheating, reseating, de-coking, burnt, pitted and sticking valves).
Timing Chains And Belts
If the timing belts or chains have been changed in accordance with
the time/mileage requirements specified by the manufacturer they
will be covered against mechanical Breakdown.
Cooling System
Water pump, engine thermostat and housing, engine temperature
sensor, engine oil cooler, radiator, expansion tank.
Fuel System
Fuel lift pump (mechanical or electrical), petrol injection pump,
carburettor.
Engine Management System
Engine electronic control unit (ECU).
Ignition System
CDI unit (electronic ignition), electronic ignition module, ignition coil.
Clutch
Release (thrust) bearing, clutch plates, master and slave cylinders,
clutch cable, (excluding lack of lubrication, worn or burnt out plates).
Gearbox
The following internal mechanical parts are covered: gears and gear
clusters, selectors and shafts, selector drum, bushes, ball, roller and
needle bearings, internal chains.
Shaft Drive
Shafts, universal joints and couplings, bearings, rubber couplings (excluding gaiters).
Wheel Bearings
Front and rear wheel bearings.
|
|
Front Suspension
Head stock bearing, yokes (excluding pitting), telescopic forks including seals, springs.
Rear Suspension
Springs, shock absorber/s including remote reservoir (excluding pipes), swinging
arm bearing and bushes.
Braking System
Brake master cylinder, calipers, (excluding corroded or seized parts).
Instruments (mechanical failure only)
Speedometer head, tachometer, fuel and temperature gauge.
Electrical System
Alternator/generator, voltage regulator, rectifier, starter motor, indicator relay, electric
radiator fan and temperature sensing switch, oil pressure sensor, indicator and light
switches (handlebar switches), fuel tank sender unit, horn.
Working Materials
Should any authorised repair to any of the above Components require replacement
or topping up of the lubricants, oils or coolant, or replacement of the oil filter, these
will constitute part of the claim within the Insurance limits.
Casings
Consequential damage to casings caused by the failure of a covered Component
will constitute part of the total claim.
|